Product ID:RHODORSIL FLUIDS 47.7 50 THROUGH V 2,500,000
MSDS Date:03/22/1995
FSC:9150
NIIN:00-292-9609
Status Code:A
MSDS Number: CJGJT

Emergency Phone: 800-334-7577

Info Phone: 201-821-3586

Cage: 0A5D1

Telephone: 504-366-9105

Cage: 0PGK2

POLYDIMETHYLSILOXANE

CAS: 63148-62-9

RTECS: JT6484500

LD50 LC50 Mixture:LD50 (ORAL, RAT) > 5,000 MG/KG;NO DEATH
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NONE. ACUTE - EYE:
NON-IRRITATING. MAY CAUSE FOREIGN BODY IRRITATION ONLY. SKIN:
NON-IRRITATING. LOW ACUTE DERMAL TOXICITY. INHALATION. THIS IS A
VISCOUS FLUID THAT DOES NOT EASILY FORM A MIST OR VAPOR AND
THEREFORE NHALATION HAZARDS ARE MINIMAL. INGESTION: LOW ACUTE ORAL
TOXICITY. CHRONIC EFFECTS - NO ADDITIONAL DATA FOUND.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
INGREDIENT DESIGNATED BY IARC, NTP, ACGIH OR OSHA AS PROBABLE OR
SUSPECTED HUMAN CARCINOGENS.
Effects of Overexposure:NAUSEA, VOMTING
Medical Cond Aggravated by Exposure:NO DATA FOUND.

First Aid:GET MEDICAL HELP IF SYMPTOMS DEVELOP OR PERSIST. INHALATION:
INHALATION IS NOT AN EXPECTED ROUTE OF EXPOSURE. IF RESPIRATORY
IRRITATION OR DISTRESS OCCURS, REMOVE VICTIM TO FRESH AIR. SEEK
MEDIAL ATTE NTION. EYE EXPOSURE: IMMEDIATELY ABSORB EXCESS WITH
CLEAN ABSORBENT CLOTH OR COTTON. THEN, HOLD EYELIDS OPEN AND FLUSH
WITH A STEADY, GENTLE STREAM OF WATER FOR AT LEAST 15 MINUTES.
SKIN EXPOSURE: WI PE EXCESS OFF SKIN WITH A DRY CLOTH; THEN WASH
SKIN WITH PLENTY OF SOAP AND WATER. INGESTION: IF VICTIM IS FULLY
CONSCIOUS, INDUCE VOMITING IMMEDIATELY BY GIVING TWO GLASSES OF
WATER AND STICKING FING ER DOWN THROAT. GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:=298.9C, 570.F
Extinguishing Media:DRY CHEMICAL, FOAM AND C02
Fire Fighting Procedures:WEAR A NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING. COOL CONTAINERS
EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:CAUTION: SPILLED MATERIAL MAY MAKE THE FLOOR
SLIPPERY. ABSORB SPILL WITH AN INERT ABSORBENT. SCRAPE UP AND PLACE
IN APPROPRIATE CLOSED CONTAINER FOR RECLAMATION OR DISPOSAL. CLEAN
UP RESIDUAL MATERIAL WITH AN APPROPRIATE SOLVENT SUCH AS PAINT
THINNER OR MINERAL SPIRIT, PROVIDED THAT THERE IS GOOD VENTILATION
AND NO IGNITION SOURCES. DO NOT FLUSH TO DRAIN.

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE, IN TIGHTLY
CLOSED CONTAINERS. DO NOT EAT, DRINK OR SMOKE IN THE WORK AREA.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID DIRECT OR PROLONGED CONTACT WITH EYES AND SKIN.
WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING AND BEFORE
EATING, DRINKING, APPLYING COSMETIC OR USING TOILET FACILITIES.
REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE REUSE.

Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION REQUIRED FOR
PRODUCT AS SOLD.
Ventilation:PROVIDE ADEQUAATE VENTILATION. USE LOCAL EXHAUST AS NEEDED.
Protective Gloves:RUBBER
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS.
Other Protective Equipment:MAINTAIN A SINK AND EYEWASH FOUNTAIN IN THE
WORK AREA.
Work Hygienic Practices:GOOD PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY
CHEMICAL BE REMOVED FROM THE SKIN AS SOON AS PRACTICAL.
Supplemental Safety and Health
ALL TREATMENTS SHOULD BE BASED ON OBSERVED SIGNS AND SYMPTOMS OF
DISTRESS IN THE PATIENT. CONSIDERATION SHOULD BE GIVEN TO THE
POSSIBLITY THAT OVEREXPOSURE TO MATERIALS OTHER THAN THIS PRODUCT
MAY HAV E OCCURRED. TREAT SYMPTOMATICALLY.

HCC:V6
Melt/Freeze Pt:<18.3C, 65.F
Vapor Pres:0.01@392F
Spec Gravity:0.96@25C
Viscosity:50CS TO 2,500,000
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, VISCOUS LIQUID/ODORLESS

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING MATERIALS AND STRONG BASES.
Stability Condition to Avoid:HEAT AND OPEN FLAME
Hazardous Decomposition Products:ON COMBUSTION, SILICA AND OXIDES OF
CARBON ARE EMITTED. FORMALDEHYDE IS A BYPRODUCT OF OXIDATIVE
THERMAL DECOMPOSITION.

Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. REUSING IS RECOMMENDED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:NOT LISTED
Federal Regulatory Information:PRODUCT IS TSCA CERTIFIED.
State Regulatory Information: